2008 Ford Cab & Chassis
Mileage
119,400
Service Date
6/2/2022
Services Performed
- —– NEEDS TRUCK @ 4PM THURSDAY ——–
- Checked and topped off engine fluid levels, checked and adjusted tire pressures, recommend engine air filter, throttle body service, cleaning of mass air flow sensor, fuel filter replacement is recommended, power steering fluid is dirty, recommend 4- tires in near future, front upper and lower ball joints have play.
- Remove and reinstall four wheels to inspect brake condition, Inspect entire system for leaks. Lining remaining is: Front (0mm) Rear (1mm). front brake rotors metal to metal. possible caliper stuck.
- CUSTOMER STATES UNDER LOAD WHISTLING NOISE CAN BE HEARD DIAGNOSE AND ADVISE
- VERIFY CONCERN. ENGINE LIGHT ON. USED SCANNER TO PULL CODES. CODES P0302 CYLINDER # 2 MISFIRE DETECTED. P0316 ENGINE MISFIRE DETECTED ON START UP. P0456 EVAP SYSTEM VERY SMALL LEAK DETECTED. P0457 EVAP SYSTEM LEAK DETECTED (FUEL CAP). PERFORMED DIAGNOSE. USED SMOKE MACHINE INTO EVAP SYSTEM. CHECKED PURGE VALVE. PURGE VALVE OK. CHECKED VENT VALVE. VENT VALVE OK. SEAL EVAP SYSTEM. CHECKED READINGS. FUEL TANK PRESSURE SENSOR AT 0 PSI. FOUND FUEL GAS CAP LEAKING. REMOVED CAP. INSTALL FUEL CAP ADAPTER. RE- TEST. FUEL TANK PRESSURE SENSOR NOW READING PRESSURE. CHECKED EVAP SYSTEM. NO LEAKS FOUND. REMOVED FUEL CAP ADAPTER. FUEL TANK PRESSURE SENSOR DROPS. USED SCANNER TO MONITOR LIVE DATA AT EACH CYLINDER. FOUND CYLINDER # 2 WITH MOST MISFIRES. REMOVED COIL # 2 AND BENCH TEST, IGNITION COIL PACK OK, REMOVED SPARK PLUG. FOUND GROUNDING TIP CRACKED ON SPARK PLUG. RECOMMEND REPLACEMENT OF SPARK PLUG AND FUEL TANK GAS CAP.
- REMOVED AND REPLACED FAILED SPARK PLUG CYLINDER #2
- PERFORMED OIL AND FILTER CHANGE.
- REMOVED FRONT BRAKE ROTORS, REMOVED WHEEL BEARINGS CLEANED AND INSPECTED, WHEEL BEARINGS OK, REPACKED WITH NEW GREASE, INSTALLED ON NEW BRAKE ROTORS WITH NEW GREASE SEALS, INSTALLED NEW BRAKE PADS, RE INSTALLED WHEELS, TEST DROVE.
- Replace rear brake pads and rear brake rotors. Clean and lubricate brake calipers and slide mechanisms. Road test vehicle.
- REMOVE ENGINE AIR FILTER COVER, CLEAN OUT AIR FILTER HOUSING, INSTALL NEW AIR FILTER.
- FUEL FILTER – Remove & Replace – F350 Super Duty,Gas In Line
- REMOVE THROTTLE BODY, ( AS NEEDED ) CLEAN CARBON BUILD UP FROM THROTTLE PLATE, RE INSTALL THROTTLE BODY WITH NEW GASKET ( WHEN THROTTLE BODY IS REMOVED ), ADJUST IDLE PARAMETERS WHERE APPLICABLE
WAYNE Z. gave our service a 5 star review on 6/20/2022
