2014 Ford F-250 Super Duty
Mileage
73,851
Service Date
3/18/2025
Services Performed
- TOWED INN
- —- TRUCK HAS NO BRAKES —–
- INSPECTED AND CONFIRMED FRONT BRAKES ARE METAL ON METAL PISTON ON BRAKE CALIPER CAME OUT AND BRAKE FLUID LEAKED OUT, WILL NEED BOTH FRONT BRAKE CALIPERS, FRONT BRAKE PADS AND ROTORS WITH WHEEL SEALS, WHEEL BEARINGS WILL NEED TO BE CLEANED AND INSPECTED.
- Checked and topped off engine fluid levels, checked and adjusted tire pressures, transmission fluid level is low, recommend differential service, will need 4-tires in near future, engine air filter is dirty, recommend engine oil and filter replacement.
- REMOVED AND REPLACED FRONT BRAKE ROTORS, REPLACED BOTH BRAKE CALIPERS INSTALLED NEW BRAKE PADS, CLEANED AND INSPECTED WHEEL BEARINGS RIGHT SIDE BEARINGS ARE PITTED, INSTALLED NEW RIGHT SIDE INNER AND OUTER BEARINGS REPACKED LEFT FRONT WHEEL BEARINGS, INSTALLED NEW SEALS.
- Check brake fluid for moisture and contamination. Inspect all hydraulic line and hoses. Inspect calipers and wheel cylinders. Inspect master cylinder and cap. Flush entire brake system including master cylinder, calipers, wheel cylinders until clean.
- Replace rear brake pads and machine rear brake rotors. Clean and lubricate brake calipers and slide mechanisms. Road test vehicle. WARRANTY ON BRAKES IS 1 YEAR OR 12,000 MILES
- REMOVE ENGINE AIR FILTER COVER, CLEAN OUT AIR FILTER HOUSING, INSTALL NEW AIR FILTER.
- DRAIN AND FILL OIL. REPLACE OIL FILTER . CHECK AND TOP OFF ALL FLUIDS AS NEEDED
- INSPECT FOR LEAKS. CHECK DIFF FLUID LEVEL. REMOVE OLD GEAR OIL REFILL WITH NEW BG GEAR OIL WITH FRICTION MODIFIER
- DRAINED TRANSMISSION FLUID, REMOVED TRANSMISSION OIL PAN, REMOVED AND REPLACED INTERNAL FILTER, CLEANED AND RE INSTALLED TRANSMISSION OIL PAN WITH NEW PAN GASKET, RE FILLED WITH NEW TRANSMISSION FLUID, TEST DROVE TO VERIFY PROPER OPERATION OF TRANSMISSION, RE INSPECTED FOR LEAKS NO LEAKS, CHECKED AND TOPPED OF TRANSMISSION FLUID LEVEL.
- Remove and Replace Four tires, installed 4- new tire pressure sensors, speed balanced tires installed and torqued lug nuts.
- AFTER REPLACEMENT OF TIRES WAS NOT ABLE TO RESET TIRE PRESSURE MONITORING SYSTEM, TIRE PRESSURE SENSOR NOT READING, REMOVED TIRES AND TEST SENSORS, FOUND SENSORS READING BATTERY VOLTAGE IS LOW, REPLACED 4- TPMS SENSOR REPROGRAMMED SENSORS TO TRUCK INSTALLED TIRES ONTO TRUCK, TPMS LIGHT STILL NOT RESETTING, PERFORMED ECM AND BCM CALIBRATIONS TPMS LIGHT STILL NOT RESETTING, RAN TSB FOR CONCERN NONE FOUND. SUBMITTED CONCERN TO TECHNICAL SUPPORT AND FOUND THAT BLUE TOOTH DEVICE PLUGGED INTO CIGARETTE LIGHTER SOCKET CAUSING INTERFERENCE WITH TPMS SYSTEM AND NOT ALLOWING SYSTEM TO FUNCTION PROPERLY, REMOVED BLUE TOOTH DEVICE, PROGRAMMED AND CALIBRATED TIRE PRESSURE MONITORING SYSTEM, ROAD TEST TRUCK CONFIRMED TPMS WARNING LIGHT IS OF NOW AND ALL TIRE PRESSURE SENSORS ARE READING WITHIN SPECS.
- Road test vehicle. Check all suspension and steering parts for wear. Check tire pressure and condition. Check riding height. Check alignment of all four wheels. Adjust toe-in, and thrust angle as needed on all four wheels. Center steering wheel, Warranty on alignment is 3 months or 3,000 miles whichever comes first, except if damage or changes been done to suspension that would cause alignment to change. Warranty work has to be performed in our shop & cannot exceed the original cost.
This vehicle's owner gave our service a 5 star review on 3/18/2025
