Call (949) 454-1000

2004 Ford Cab & Chassis

//2004 Ford Cab & Chassis

2004 Ford Cab & Chassis

Ford Cab & Chassis

Mileage
112,736
Service Date
11/25/2020
Services Performed
  • CALIFORNIA EMISSIONS (SMOG) INSPECTION
  • Checked and topped off engine fluid levels, checked and adjusted tire pressures
  • DRAIN ENGINE OIL AND REPLACE OIL FILTER, REFILL ENGINE OIL WITH FACTORY RECOMMENDED OIL AND CHECK ALL FLUID LEVELS, RESET OIL LIGHT IF APPLICABLE
  • Inspect hoses and clamps. Pressure test cooling system. Flush engine, radiator, and heater core in both directions. Bring antifreeze to -35 degrees. PH balance coolant to between 9.8 to 10.5. Check thermostat and electric cooling fan operation. Chec
  • PER CUSTOMERS REQUEST PERFORM THE FOLLOWING SERVICES CHECK AND ADVISE oil change Transmission service Both differtial service Fuel filters Radiator flush Smog
  • Remove cover. Remove old gasket material, drain old fluid, inspect internals and reassemble with new gasket. Install new fluid to proper levels, BOTH FRONT AND REAR DIFFERENTIALS, DRAIN AND RE FILL TRANSFER CASE FLUID.
  • REMOVED AND REPLACED EGR VALVE RESET KAM CLEAR ALL CODES AND ROADTEST VEHICLE
  • REMOVED AND REPLACED PRIMARY AND SECONDARY FUEL FILTERS
  • REMOVED AND REPLACED TURBO CLEAR ALL CODES AND ROADTEST VEHICLE
  • REMOVED TRANS PAN AND REPLACE INTERNAL FILTER , RE INSTALL PAN ALONG WITH NEW GASKET FILL SYSTEM WITH NEW FLUID
  • RETRIEVED DTCS P0403, P0299 EGR EXCESSIVE FLOW AND TURBO OVERBOOST CODES, PERFORM EGR SYSTEM TEST FOUND VALVE FAILING POSITION TEST VALVE WOULD NOT OPEN COMPLETELY, PERFORM TURBO SYSTEM TEST FOUND TURBO STICKING CAUSING OVERBOOST CONDITION ADVISE CUSTOMER NEED TO START WITH EGR AND TURBO REPAIRS AND RETEST BEFORE EMISSIONS MONITORS WILL RESET
  • ROTATED TIRES FRONT TO BACK AND SET TIRE PRESSURE
  • REBUILT TURBO ( 1-YEAR UNLIMITED MILEAGE WARRANTY )
  • WASH AND VACUUM TRUCK
 
CRAIG F. gave our service a 5 star review on 11/30/2020
2020-12-01T23:01:01+00:00